To the top of the document
Volt
   
GMDE Start Page Load static TOC Load dynamic TOC Help?

Front Wheel Speed Sensor Replacement

Removal Procedure

    Warning: Refer to Brake Dust Warning in the Preface section.

    Danger: Do not use a service jack in locations other than those specified to lift this vehicle. Lifting the vehicle with a jack in those other locations could cause the vehicle to slip off the jack and roll; this could cause injury or death.

  1. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle .
  2. Remove the tyre and wheel assembly. Refer to Tyre and Wheel Removal and Installation .
  3. Remove the 11 lower fasteners securing the front wheelhouse liner front liner to the frame. Refer to Front Wheelhouse Front Liner Replacement .
  4. Pull the front wheelhouse liner away from the frame to access the wheel speed sensor electrical connector.

    5. 2278444
  5. Disconnect the wheel speed sensor electrical connector (1) and release the connector from the frame.
  6. Release the harness clip (2) from the frame.
  7. Release the harness clips (3) from the lower control arm.

    8. 2278445
  8. Clean the wheel speed sensor mounting area on the steering knuckle of any accumulated dirt and debris.
  9. Remove the wheel speed sensor bolt (1).

    10. 2278446
  10. Remove the wheel speed sensor (1) from the steering knuckle.
  11. Release the harness clip (2) from the steering knuckle and remove the wheel speed sensor.

Installation Procedure

    2278446
  1. Install the wheel speed sensor (1) to the steering knuckle.
  2. Install the harness clip (2) to the steering knuckle.

    3. Caution: Refer to Fastener Caution in the Preface section.


    2278445
  3. Install the wheel speed sensor bolt (1) and tighten to 10 N·m (89 lb in).

    4. 2278444
  4. Connect the wheel speed sensor electrical connector (1) and secure the connector to the frame.
  5. Install the harness clip (2) to the frame.
  6. Install the harness clips (3) to the lower control arm.
  7. Install the 11 lower fasteners securing the front wheelhouse liner front liner to the frame. Refer to Front Wheelhouse Front Liner Replacement .
  8. Install the tyre and wheel assembly. Refer to Tyre and Wheel Removal and Installation .
  9. Perform the Diagnostic System Check - Vehicle .
   


© Copyright Chevrolet. All rights reserved